北京赛车pk10赚钱软件
  常见问题
   北京赛车pk10赚钱软件简介
   产品展示
   北京赛车pk10赚钱软件新闻
   销售网络
   客户服务
   人力资源
   常见问题
   联系我们
当前位置:北京赛车pk10赚钱软件首页 > 常见问题
减速电机故障原因与措施
故障
Malfunction
原因
Causes
措施
Measures
在减速机的紧固件处有大的噪声
High noise at tightening parts
紧固件松动了
Loose of tightening parts
将螺栓/螺母拧紧到规定的扭矩。更换损坏了的螺栓/螺母。
Tighten nut bolt to correct state Replace damaged nut/bolt
减速机的噪声变化
Changing noise
齿轮的轮齿发生了损坏
Teeth of gears get damaged
和客户服务部联系。检查所有零件上的齿,更换损坏了的零件。
Consult after-sales department
Check teeth of gears and replace damaged one.
轴承间隙过大
Clearance of bearings too big
和售后服务部联系。
调整轴承的间隙。
Consult after-sales department
Adjust the clearance of bearings
轴承损坏
Bearings get damaged
和客户服务部联系。
更换损坏的轴承。
Consult after-sales department
Replace damaged bearings
轴承温度升高
Bearing temperature rise
箱体里面的油面过高或过低
Oillevel is too high or low
在室温下检查油面的高度并按需加油。
Check oil level at room temperature and add on reduce oil
油过于陈旧
Oil is used too long
和售后服务部联系。
检查上次换油的时间。
Consult after-sales department.
Check the date that oil be replaced last time.
油泵的机械故障
Malfunction of oil pump
和售后服务部联系。
检查油泵的工作是否正常,修理或换新的油泵。
Consult after-sales department.
Check if pump works normally,repair or replace it.
轴承损坏
Bearing damage
和售后服务部联系。
-查阅操作人员在振动测量中所获得的数据。
-检查并按需要换轴承。
Consult after-sales department.
-Look up the date about vibration.
-Check and replace it on request.
工作温度过高
Working temperature too high
箱体里面的油面过高
Oil level is too high
检查油面的高度,如果有必要的话,调整。
Check oil level,and adjust if necessary.
油过于陈旧
Oil is used too long
和售后服务部联系。
检查上一次换油的时间,如果有必要的话就更换。
Consult after-sales department.
Check the date that oil was replaced last time,
replace it if necessary
油受到严重污染
Oil is pollucted seriously
和售后服务部联系
-换油。
Consult after-sales department.
-Replace oil.
在配备了润滑油冷却系统的减速机上:冷却剂的流量过低或者过高
Flux of cooling material is too high or low
全面调节进口和出口管道的阀门。
检查水冷装置的自由流量。
Adjust entrance and exit valves.
Check the flux of water cooling devices.
通过水冷装置的油流过低,其原因是:滤油器严重堵塞
Oil flux through water cooling devices is too low
清理滤油器
Clean oil filter
油泵的机械故障
油泵损坏
Malfunction of oil pump
Oil pump damage
和售后服务部联系。
-检查油泵的功能是否正常。
-修理或者换新。
Consult after-sales department.
-Check of oil pump works normally.
-Repair or replace it.
在配备了风扇的减速机上:风扇罩的空气入口和/或箱体严重污染
Entrance of fan shield and housing polluted seriously
清理风扇罩和箱体
Cleanse fan shield and housing.
配备了冷却螺旋管的减速机:冷却螺旋管里面结垢
Redsidues in cooling coil
和售后服务部联系。
-清理或者更换螺旋管。
Consult after-sales department.
-Claen or replace cooling coil.
轴承处的振幅升高
Swing at bearing higher
轴承损坏
Bearing is damaged
和售后服务部联系。
-检查并按需更换轴承。
Consult after-sales department
-Check and replace bearing.
齿轮损坏
Gear is damaged
和售后服务部联系。
-检查并按需更换齿轮。
Consult after-sales department.
-Check and replaces gears.
止回装置的温度过高
止回功能的失效
Temperature of anti-backstop too high and it becomes malfunction
止回装置损坏
Anti-backstop becomes malfunction
和售后服务部联系。
-检查并按需更换止回装置。
Consult after-sales department.
-Replace anti-backstop
减速机漏油
Oil-leak of gear unit
箱体盖或者联接处的密封不良
Sealing at cover and connection not in good state
检查密封和连接处,如果必要的话,更换新的。将连接处密封好。
Check air-proof and connection part,replace them if necessary,and seal up connection part.
径向轴封失效
Shaft seal is malfunction
和售后服务部联系。
-换新的径向密封环。
Consult after-sales department.
油中有水
Water in oil
油中有杂物
Mixer in oil
用试管检查油的状态是否有水分存在。
实验室分析油.
Classify if there is water in oil by using tube.
Analyse oil in laboratory.
润滑油冷却器或者冷却螺旋管失效。
Cooling coil is of mal-fanction
和售后服务部联系。
-找出并修理泄漏之处。
-更换冷却器或者螺旋管。
Consult after-sales department.
-Find out and repair leakage place.
-replace cooling coil
减速机受到机器间通风过来的凉空气而产生凝露
Cool air will cause water drop in gear unit.
用合适的保温材料将减速机保护起来。
关闭空气的出口或者在结构上改变其方向。
Shelter gear units with proper
注:对于客户自己无法排除的故障请和我北京赛车pk10赚钱软件售后服务部联系。
Note: Please consult after-sales department, if malfunction can not be removed by consumers tehmselves.
COPYRIGHT 2012 浙江永嘉路得传动机械有限北京赛车pk10赚钱软件 北京赛车pk10赚钱软件版权所有